Bhopal disaster

In 1976, two local trade unions complained of pollution within the plant.[6][14] In 1981, a worker was accidentally splashed with phosgene as he was carrying out a maintenance job of the plant's pipes. In a panic, he removed his gas mask and inhaled a large amount of toxic phosgene gas, leading to his death just 72 hours later.[6][14] Following these events, journalist Rajkumar Keswani began investigating and published his findings in Bhopal's local paper Rapat, in which he urged "Wake up people of Bhopal, you are on the edge of a volcano".[15][16]

In January 1982, a phosgene leak exposed 24 workers, all of whom were admitted to a hospital. None of the workers had been ordered to wear protective masks. One month later, in February 1982, a MIC leak affected 18 workers. In August 1982, a chemical engineer came into contact with liquid MIC, resulting in burns over 30 percent of his body. Later that same year, in October 1982, there was another MIC leak. In attempting to stop the leak, the MIC supervisor suffered severe chemical burns and two other workers were severely exposed to the gases. During 1983 and 1984, there were leaks of MIC, chlorine, monomethylamine, phosgene, and carbon tetrachloride, sometimes in combination.[6][14]

The Bhopal UCIL facility housed three underground 68,000-liter liquid MIC storage tanks: E610, E611, and E619. In the months leading up to the December leak, liquid MIC production was in progress and being used to fill these tanks. UCC safety regulations specified that no one tank should be filled more than 50% (here, 30 tons) with liquid MIC. Each tank was pressurized with inert nitrogen gas. This pressurization allowed liquid MIC to be pumped out of each tank as needed, and also kept impurities out of the tanks.[17]

In late October 1984, tank E610 lost the ability to effectively contain most of its nitrogen gas pressure, which meant that the liquid MIC contained within could not be pumped out. At the time of this failure, tank E610 contained 42 tons of liquid MIC.[17][18] Shortly after this failure, MIC production was halted at the Bhopal facility, and parts of the plant were shut down for maintenance. Maintenance included the shutdown of the plant's flare tower so that a corroded pipe could be repaired.[17] With the flare tower still out of service, production of carbaryl was resumed in late November, using MIC stored in the two tanks still in service. An attempt to re-establish pressure in tank E610 on 1 December failed, so the 42 tons of liquid MIC contained within still could not be pumped out of it.[18]

Tank 610 in 2010. During decontamination of the plant, tank 610 was removed from its foundation and left aside.

Methylamine (1) reacts with phosgene (2) producing methyl isocyanate (3) which reacts with 1-naphthol (4) to yield carbaryl (5).

By early December 1984, most of the plant's MIC related safety systems were malfunctioning and many valves and lines were in poor condition. In addition, several vent gas scrubbers had been out of service as well as the steam boiler, intended to clean the pipes.[6] During the late evening hours of 2 December 1984, water was believed to have entered a side pipe and into Tank E610 whilst trying to unclog it, which contained 42 tons of MIC that had been there since late October.[6] The introduction of water into the tank subsequently resulted in a runaway exothermic reaction, which was accelerated by contaminants, high ambient temperatures and various other factors, such as the presence of iron from corroding non-stainless steel pipelines.[6] The pressure in tank E610, although initially normal at 10:30 p.m., had increased by a factor of five to 10 psi (34.5 to 69 kPa) by 11 p.m. Two different senior refinery employees assumed the reading was instrumentation malfunction.[19] By 11:30 p.m., workers in the MIC area were feeling the effects of minor exposure to MIC gas, and began to look for a leak. One was found by 11:45 p.m., and reported to the MIC supervisor on duty at the time. The decision was made to address the problem after a 12:15 a.m. tea break, and in the meantime, employees were instructed to continue looking for leaks. The incident was discussed by MIC area employees during the break.[19]

In the five minutes after the tea break ended at 12:40 a.m., the reaction in tank E610 reached a critical state at an alarming speed. Temperatures in the tank were off the scale, maxed out beyond 25 °C (77 °F), and the pressure in the tank was indicated at 40 psi (275.8 kPa). One employee witnessed a concrete slab above tank E610 crack as the emergency relief valve burst open, and pressure in the tank continued to increase to 55 psi (379.2 kPa) even after atmospheric venting of toxic MIC gas had begun.[19] Direct atmospheric venting should have been prevented or at least partially mitigated by at least three safety devices which were malfunctioning, not in use, insufficiently sized or otherwise rendered inoperable:[20][21]

• A refrigeration system meant to cool tanks containing liquid MIC, shut down in January 1982, and whose freon had been removed in June 1984. Since the MIC storage system assumed refrigeration, its high temperature alarm, set to sound at 11 °C (52 °F) had long since been disconnected, and tank storage temperatures ranged between 15 °C (59 °F) and 40 °C (104 °F)[22]
• A flare tower, to burn the MIC gas as it escaped, which had had a connecting pipe removed for maintenance, and was improperly sized to neutralise a leak of the size produced by tank E610
• A vent gas scrubber, which had been deactivated at the time and was in 'standby' mode, and similarly had insufficient caustic soda and power to safely stop a leak of the magnitude produced

About 30 tonnes of MIC escaped from the tank into the atmosphere in 45 to 60 minutes.[3] This would increase to 40 tonnes within two hours time.[23] The gases were blown in a southeasterly direction over Bhopal.[6][24]

A UCIL employee triggered the plant's alarm system at 12:50 a.m. as the concentration of gas in and around the plant became difficult to tolerate.[19][23] Activation of the system triggered two siren alarms: one that sounded inside the UCIL plant, and a second directed outward to the public and the city of Bhopal. The two siren systems had been decoupled from one another in 1982, so that it was possible to leave the factory warning siren on while turning off the public one, and this is exactly what was done: the public siren briefly sounded at 12:50 a.m. and was quickly turned off, as per company procedure meant to avoid alarming the public around the factory over tiny leaks.[23][25][26] Workers, meanwhile, evacuated the UCIL plant, travelling upwind.

Bhopal's superintendent of police was informed by telephone, by a town inspector, that residents of the neighbourhood of Chola (about 2 km from the plant) were fleeing a gas leak at approximately 1 a.m.[25] Calls to the UCIL plant by police between 1:25 and 2:10 a.m. gave assurances twice that "everything is OK", and on the last attempt made, "we don't know what has happened, sir".[25] With the lack of timely information exchange between UCIL and Bhopal authorities, the city's Hamidia Hospital was first told that the gas leak was suspected to be ammonia, then phosgene. Finally, they received an updated report that it was "MIC" (rather than "methyl isocyanate"), which hospital staff had never heard of, had no antidote for, and received no immediate information about.[27]

The MIC gas leak emanating from tank E610 petered out at approximately 2:00 a.m. Fifteen minutes later, the plant's public siren was sounded for an extended period of time, after first having been quickly silenced an hour and a half earlier.[28] Some minutes after the public siren sounded, a UCIL employee walked to a police control room to both inform them of the leak (their first acknowledgement that one had occurred at all), and that "the leak had been plugged."[28] Most city residents who were exposed to the MIC gas were first made aware of the leak by exposure to the gas itself, or by opening their doors to investigate commotion, rather than having been instructed to shelter in place, or to evacuate before the arrival of the gas in the first place.[26]

Reversible reaction of glutathione (top) with methyl isocyanate (MIC, middle) allows the MIC to be transported into the body.

The initial effects of exposure were coughing, severe eye irritation and a feeling of suffocation, burning in the respiratory tract, blepharospasm, breathlessness, stomach pains and vomiting. People awakened by these symptoms fled away from the plant. Those who ran inhaled more than those who had a vehicle to ride. Owing to their height, children and other people of shorter stature inhaled higher concentrations, as methyl isocyanate gas is approximately twice as dense as air and hence in an open environment has a tendency to fall toward the ground.[29]

Thousands of people had died by the following morning. Primary causes of deaths were choking, reflexogenic circulatory collapse and pulmonary oedema. Findings during autopsies revealed changes not only in the lungs but also cerebral oedema, tubular necrosis of the kidneys, fatty degeneration of the liver and necrotising enteritis.[30] The stillbirth rate increased by up to 300% and neonatal mortality rate by around 200%.[6]

Apart from MIC, based on laboratory simulation conditions, the gas cloud most likely also contained chloroform, dichloromethane, hydrogen chloride, methylamine, dimethylamine, trimethylamine and carbon dioxide, that was either present in the tank or was produced in the storage tank when MIC, chloroform and water reacted. The gas cloud, composed mainly of materials denser than air, stayed close to the ground and spread in the southeasterly direction affecting the nearby communities.[29] The chemical reactions may have produced a liquid or solid aerosol.[31] Laboratory investigations by CSIR and UCC scientists failed to demonstrate the presence of hydrogen cyanide.[29][32]

In the immediate aftermath, the plant was closed to outsiders (including UCC) by the Indian government, which subsequently failed to make data public, contributing to the confusion. The initial investigation was conducted entirely by the Council of Scientific and Industrial Research (CSIR) and the Central Bureau of Investigation. The UCC chairman and CEO Warren Anderson, together with a technical team, immediately traveled to India. Upon arrival Anderson was placed under house arrest and urged by the Indian government to leave the country within 24 hours. Union Carbide organized a team of international medical experts, as well as supplies and equipment, to work with the local Bhopal medical community, and the UCC technical team began assessing the cause of the gas leak.

The health care system immediately became overloaded. In the severely affected areas, nearly 70 percent were under-qualified doctors. Medical staff were unprepared for the thousands of casualties. Doctors and hospitals were not aware of proper treatment methods for MIC gas inhalation.[6]^:6

There were mass funerals and cremations. Photographer Pablo Bartholemew, on commission with press agency Rapho, took an iconic color photograph of a burial on 4 December, Bhopal gas disaster girl. Another photographer present, Raghu Rai, took a black and white photo. The photographers did not ask for the identity of the father or child as she was buried, and no relative has since confirmed it. As such, the identity of the girl remains unknown. Both photos became symbolic of the suffering of victims of the Bhopal disaster, and Bartholomew's went on to win the 1984 World Press Photo of the Year.[33]

Within a few days, trees in the vicinity became barren and bloated animal carcasses had to be disposed of. 170,000 people were treated at hospitals and temporary dispensaries, and 2,000 buffalo, goats, and other animals were collected and buried. Supplies, including food, became scarce owing to suppliers' safety fears. Fishing was prohibited causing further supply shortages.[6]

Lacking any safe alternative, on 16 December, tanks 611 and 619 were emptied of the remaining MIC by reactivating the plant and continuing the manufacture of pesticide. Despite safety precautions such as having water carrying helicopters continually overflying the plant, this led to a second mass evacuation from Bhopal. The Government of India passed the "Bhopal Gas Leak Disaster Act" that gave the government rights to represent all victims, whether or not in India. Complaints of lack of information or misinformation were widespread. An Indian government spokesman said, "Carbide is more interested in getting information from us than in helping our relief work".[6]

Formal statements were issued that air, water, vegetation and foodstuffs were safe, but warned not to consume fish. The number of children exposed to the gases was at least 200,000.[6] Within weeks, the State Government established a number of hospitals, clinics and mobile units in the gas-affected area to treat the victims.

Victims of Bhopal disaster march in September 2006 demanding the extradition of American Warren Anderson from the United States.

Legal proceedings involving UCC, the United States and Indian governments, local Bhopal authorities, and the disaster victims started immediately after the catastrophe. The Indian Government passed the Bhopal Gas Leak Act in March 1985, allowing the Government of India to act as the legal representative for victims of the disaster,[34] leading to the beginning of legal proceedings. Initial lawsuits were generated in the United States federal court system. On 17 April 1985, Federal District court judge John F. Keenan (overseeing one lawsuit) suggested that "'fundamental human decency' required Union Carbide to provide between $5 million and $10 million to immediately help the injured" and suggested the money could be quickly distributed through the International Red Cross.[35] UCC, on the notion that doing so did not constitute an admission of liability and the figure could be credited toward any future settlement or judgement, offered a $5 million relief fund two days later.[35] The Indian government turned down the offer.[29]

In March 1986 UCC proposed a settlement figure, endorsed by plaintiffs' U.S. attorneys, of $350 million that would, according to the company, "generate a fund for Bhopal victims of between $500–600 million over 20 years". In May, litigation was transferred from the United States to Indian courts by a U.S. District Court ruling. Following an appeal of this decision, the U.S. Court of Appeals affirmed the transfer, judging, in January 1987, that UCIL was a "separate entity, owned, managed and operated exclusively by Indian citizens in India".[34]

The Government of India refused the offer from Union Carbide and claimed US$3.3 billion.[6] The Indian Supreme Court told both sides to come to an agreement and "start with a clean slate" in November 1988.[34] Eventually, in an out-of-court settlement reached in February 1989, Union Carbide agreed to pay US$470 million for damages caused in the Bhopal disaster.[6] The amount was immediately paid.

Throughout 1990, the Indian Supreme Court heard appeals against the settlement. In October 1991, the Supreme Court upheld the original $470 million, dismissing any other outstanding petitions that challenged the original decision. The Court ordered the Indian government "to purchase, out of settlement fund, a group medical insurance policy to cover 100,000 persons who may later develop symptoms" and cover any shortfall in the settlement fund. It also requested UCC and its subsidiary UCIL "voluntarily" fund a hospital in Bhopal, at an estimated $17 million, to specifically treat victims of the Bhopal disaster. The company agreed to this.[34]

In 1991, the local Bhopal authorities charged Anderson, who had retired in 1986, with manslaughter, a crime that carries a maximum penalty of 10 years in prison. He was declared a fugitive from justice by the Chief Judicial Magistrate of Bhopal on 1 February 1992 for failing to appear at the court hearings in a culpable homicide case in which he was named the chief defendant. Orders were passed to the Government of India to press for an extradition from the United States. The U.S. Supreme Court refused to hear an appeal of the decision of the lower federal courts in October 1993, meaning that victims of the Bhopal disaster could not seek damages in a U.S. court.[34]

In 2004, the Indian Supreme Court ordered the Indian government to release any remaining settlement funds to victims. And in September 2006, the Welfare Commission for Bhopal Gas Victims announced that all original compensation claims and revised petitions had been "cleared".[34] The Second Circuit Court of Appeals in New York City upheld the dismissal of remaining claims in the case of Bano v. Union Carbide Corporation in 2006. This move blocked plaintiffs' motions for class certification and claims for property damages and remediation. In the view of UCC, "the ruling reaffirms UCC's long-held positions and finally puts to rest—both procedurally and substantively—the issues raised in the class action complaint first filed against Union Carbide in 1999 by Haseena Bi and several organisations representing the residents of Bhopal".[34]

In June 2010, seven former employees of UCIL, all Indian nationals and many in their 70s, were convicted of causing death by negligence: Keshub Mahindra, former non-executive chairman of Union Carbide India Limited; V. P. Gokhale, managing director; Kishore Kamdar, vice-president; J. Mukund, works manager; S. P. Chowdhury, production manager; K. V. Shetty, plant superintendent; and S. I. Qureshi, production assistant. They were each sentenced to two years’ imprisonment and fined ₹100,000 (equivalent to ₹170,000 or US$2,400 in 2018). All were released on bail shortly after the verdict.

US federal class action litigation, Sahu v. Union Carbide and Warren Anderson, was filed in 1999 under the U.S. Alien Torts Claims Act (ATCA), which provides for civil remedies for "crimes against humanity."[36] It sought damages for personal injury, medical monitoring and injunctive relief in the form of clean-up of the drinking water supplies for residential areas near the Bhopal plant. The lawsuit was dismissed in 2012 and the subsequent appeal was denied.[37] Former UCC CEO Anderson, then 92 years old, died on 29 September 2014.[38]

Some data about the health effects are still not available. The Indian Council of Medical Research (ICMR) was forbidden to publish health effect data until 1994.[6]

A total of 36 wards were marked by the authorities as being "gas affected," affecting a population of 520,000. Of these, 200,000 were below 15 years of age, and 3,000 were pregnant women. The official immediate death toll was 2,259, and in 1991, 3,928 deaths had been officially certified. Ingrid Eckerman estimated 8,000 died within two weeks.[6][39]

The government of Madhya Pradesh confirmed a total of 3,787 deaths related to the gas release.[4]

Later, the affected area was expanded to include 700,000 citizens. A government affidavit in 2006 stated the leak caused 558,125 injuries including 38,478 temporary partial injuries and approximately 3,900 severely and permanently disabling injuries.[5]

A cohort of 80,021 exposed people was registered, along with a control group, a cohort of 15,931 people from areas not exposed to MIC. Nearly every year since 1986, they have answered the same questionnaire. It shows overmortality and overmorbidity in the exposed group. Bias and confounding factors cannot be excluded from the study. Because of migration and other factors, 75% of the cohort is lost, as the ones who moved out are not followed.[6][40]

A number of clinical studies are performed. The quality varies, but the different reports support each other.[6] Studied and reported long term health effects are:

• Eyes: Chronic conjunctivitis, scars on cornea, corneal opacities, early cataracts
• Respiratory tracts: Obstructive and/or restrictive disease, pulmonary fibrosis, aggravation of TB and chronic bronchitis
• Neurological system: Impairment of memory, finer motor skills, numbness etc.
• Psychological problems: Post traumatic stress disorder (PTSD)
• Children's health: Peri- and neonatal death rates increased. Failure to grow, intellectual impairment, etc.

Missing or insufficient fields for research are female reproduction, chromosomal aberrations, cancer, immune deficiency, neurological sequelae, post traumatic stress disorder (PTSD) and children born after the disaster. Late cases that might never be highlighted are respiratory insufficiency, cardiac insufficiency (cor pulmonale), cancer and tuberculosis. Bhopal now has high rates of birth defects and records a miscarriage rate 7x higher than the national average.[16]

A 2014 report in Mother Jones quotes a "spokesperson for the Bhopal Medical Appeal, which runs free health clinics for survivors" as saying "An estimated 120,000 to 150,000 survivors still struggle with serious medical conditions including nerve damage, growth problems, gynecological disorders, respiratory issues, birth defects, and elevated rates of cancer and tuberculosis."[41]

The Government of India had focused primarily on increasing the hospital-based services for gas victims thus hospitals had been built after the disaster. When UCC wanted to sell its shares in UCIL, it was directed by the Supreme Court to finance a 500-bed hospital for the medical care of the survivors. Thus, Bhopal Memorial Hospital and Research Centre (BMHRC) was inaugurated in 1998 and was obliged to give free care for survivors for eight years. BMHRC was a 350-bedded super speciality hospital where heart surgery and hemodialysis were done. There was a dearth of gynaecology, obstetrics and paediatrics. Eight mini-units (outreach health centres) were started and free health care for gas victims were to be offered until 2006.[6] The management had also faced problems with strikes, and the quality of the health care being disputed.[42][43] Sambhavna Trust is a charitable trust, registered in 1995, that gives modern as well as ayurvedic treatments to gas victims, free of charge.[6][44]

When the factory was closed in 1986, pipes, drums and tanks were sold. The MIC and the Sevin plants are still there, as are storages of different residues. Isolation material is falling down and spreading.[6] The area around the plant was used as a dumping area for hazardous chemicals. In 1982 tubewells in the vicinity of the UCIL factory had to be abandoned and tests in 1989 performed by UCC's laboratory revealed that soil and water samples collected from near the factory and inside the plant were toxic to fish.[45] Several other studies had also shown polluted soil and groundwater in the area. Reported polluting compounds include 1-naphthol, naphthalene, Sevin, tarry residue, mercury, toxic organochlorines, volatile organochlorine compounds, chromium, copper, nickel, lead, hexachloroethane, hexachlorobutadiene, and the pesticide HCH.[6]

In order to provide safe drinking water to the population around the UCIL factory, Government of Madhya Pradesh presented a scheme for improvement of water supply.[46] In December 2008, the Madhya Pradesh High Court decided that the toxic waste should be incinerated at Ankleshwar in Gujarat, which was met by protests from activists all over India.[47] On 8 June 2012, the Centre for incineration of toxic Bhopal waste agreed to pay ₹250 million (US$3.6 million) to dispose of UCIL chemical plants waste in Germany.[48] On 9 August 2012, Supreme court directed the Union and Madhya Pradesh Governments to take immediate steps for disposal of toxic waste lying around and inside the factory within six months.[49]

A U.S. court rejected the lawsuit blaming UCC for causing soil and water pollution around the site of the plant and ruled that responsibility for remedial measures or related claims rested with the State Government and not with UCC.[50] In 2005, the state government invited various Indian architects to enter their "concept for development of a memorial complex for Bhopal gas tragedy victims at the site of Union Carbide". In 2011, a conference was held on the site, with participants from European universities which was aimed for the same.[51][52]

33 of the 50 planned work-sheds for gas victims started. All except one was closed down by 1992. 1986, the MP government invested in the Special Industrial Area Bhopal. 152 of the planned 200 work sheds were built and in 2000, 16 were partially functioning. It was estimated that 50,000 persons need alternative jobs, and that less than 100 gas victims had found regular employment under the government's scheme. The government also planned 2,486 flats in two- and four-story buildings in what is called the "widow's colony" outside Bhopal. The water did not reach the upper floors and it was not possible to keep cattle which were their primary occupation. Infrastructure like buses, schools, etc. were missing for at least a decade.[6]

Immediate relieves were decided two days after the tragedy. Relief measures commenced in 1985 when food was distributed for a short period along with ration cards.[6] Madhya Pradesh government's finance department allocated ₹874 million (US$13 million) for victim relief in July 1985.[53][54] Widow pension of ₹200 (US$2.90)/per month (later ₹750 (US$11)) were provided. The government also decided to pay ₹1,500 (US$22) to families with monthly income ₹500 (US$7.20) or less. As a result of the interim relief, more children were able to attend school, more money was spent on treatment and food, and housing also eventually improved. From 1990 interim relief of ₹200 (US$2.90) was paid to everyone in the family who was born before the disaster.[6]

The final compensation, including interim relief for personal injury was for the majority ₹25,000 (US$360). For death claim, the average sum paid out was ₹62,000 (US$900). Each claimant were to be categorised by a doctor. In court, the claimants were expected to prove "beyond reasonable doubt" that death or injury in each case was attributable to exposure. In 1992, 44 percent of the claimants still had to be medically examined.[6]

By the end of October 2003, according to the Bhopal Gas Tragedy Relief and Rehabilitation Department, compensation had been awarded to 554,895 people for injuries received and 15,310 survivors of those killed. The average amount to families of the dead was $2,200.[55]

In 2007, 1,029,517 cases were registered and decided. Number of awarded cases were 574,304 and number of rejected cases 455,213. Total compensation awarded was ₹15,465 million (US$220 million).[46] On 24 June 2010, the Union Cabinet of the Government of India approved a ₹12,650 million (US$180 million) aid package which would be funded by Indian taxpayers through the government.[56]

In 1985, Henry Waxman, a California Democrat, called for a U.S. government inquiry into the Bhopal disaster, which resulted in U.S. legislation regarding the accidental release of toxic chemicals in the United States.[57]

This point of view argues that management (and to some extent, local government) underinvested in safety, which allowed for a dangerous working environment to develop. Factors cited include the filling of the MIC tanks beyond recommended levels, poor maintenance after the plant ceased MIC production at the end of 1984, allowing several safety systems to be inoperable due to poor maintenance, and switching off safety systems to save money— including the MIC tank refrigeration system which could have mitigated the disaster severity, and non-existent catastrophe management plans.[6][39] Other factors identified by government inquiries included undersized safety devices and the dependence on manual operations.[6] Specific plant management deficiencies that were identified include the lack of skilled operators, reduction of safety management, insufficient maintenance, and inadequate emergency action plans.[6][14]

Underinvestment is cited as contributing to an environment. In attempts to reduce expenses, $1.25 million of cuts were placed upon the plant which affected the factory's employees and their conditions.[16] Kurzman argues that "cuts ... meant less stringent quality control and thus looser safety rules. A pipe leaked? Don't replace it, employees said they were told ... MIC workers needed more training? They could do with less. Promotions were halted, seriously affecting employee morale and driving some of the most skilled ... elsewhere".[62] Workers were forced to use English manuals, even though only a few had a grasp of the language.[59][63]

Subsequent research highlights a gradual deterioration of safety practices in regard to the MIC, which had become less relevant to plant operations. By 1984, only six of the original twelve operators were still working with MIC and the number of supervisory personnel had also been halved. No maintenance supervisor was placed on the night shift and instrument readings were taken every two hours, rather than the previous and required one-hour readings.[59][62] Workers made complaints about the cuts through their union but were ignored. One employee was fired after going on a 15-day hunger strike. 70% of the plant's employees were fined before the disaster for refusing to deviate from the proper safety regulations under pressure from the management.[59][62]

In addition, some observers, such as those writing in the Trade Environmental Database (TED) Case Studies as part of the Mandala Project from American University, have pointed to "serious communication problems and management gaps between Union Carbide and its Indian operation", characterised by "the parent companies [sic] hands-off approach to its overseas operation" and "cross-cultural barriers".[64]

The factory was not well equipped to handle the gas created by the sudden addition of water to the MIC tank. The MIC tank alarms had not been working for four years and there was only one manual back-up system, compared to a four-stage system used in the United States.[6][39][59][65] The flare tower and several vent gas scrubbers had been out of service for five months before the disaster. Only one gas scrubber was operating: it could not treat such a large amount of MIC with sodium hydroxide (caustic soda), which would have brought the concentration down to a safe level.[65] The flare tower could only handle a quarter of the gas that leaked in 1984, and moreover it was out of order at the time of the incident.[6][39][59][66] To reduce energy costs, the refrigeration system was idle. The MIC was kept at 20 degrees Celsius, not the 4.5 degrees advised by the manual.[6][39][59][65] Even the steam boiler, intended to clean the pipes, was non-operational for unknown reasons.[6][39][59][65] Slip-blind plates that would have prevented water from pipes being cleaned from leaking into the MIC tanks, had the valves been faulty, were not installed and their installation had been omitted from the cleaning checklist.[6][39][59] As MIC is water-soluble, deluge guns were in place to contain escaping gases from the stack. The water pressure was too weak for the guns to spray high enough to reach the gas which would have reduced the concentration of escaping gas significantly.[6][39][59][65] In addition to it, carbon steel valves were used at the factory, even though they were known to corrode when exposed to acid.[12]

According to the operators, the MIC tank pressure gauge had been malfunctioning for roughly a week. Other tanks were used, rather than repairing the gauge. The build-up in temperature and pressure is believed to have affected the magnitude of the gas release.[6][39][59][65] UCC admitted in their own investigation report that most of the safety systems were not functioning on the night of 3 December 1984.[67] The design of the MIC plant, following government guidelines, was "Indianized" by UCIL engineers to maximise the use of indigenous materials and products. Mumbai-based Humphreys and Glasgow Consultants Pvt. Ltd., were the main consultants, Larsen & Toubro fabricated the MIC storage tanks, and Taylor of India Ltd. provided the instrumentation.[29] In 1998, during civil action suits in India, it emerged that the plant was not prepared for problems. No action plans had been established to cope with incidents of this magnitude. This included not informing local authorities of the quantities or dangers of chemicals used and manufactured at Bhopal.[6][12][39][59]

Safety audits were done every year in the US and European UCC plants, but only every two years in other parts of the world.[6][68] Before a "Business Confidential" safety audit by UCC in May 1982, the senior officials of the corporation were well aware of "a total of 61 hazards, 30 of them major and 11 minor in the dangerous phosgene/methyl isocyanate units" in Bhopal.[6][69] In the audit 1982, it was indicated that worker performance was below standards.[6][61] Ten major concerns were listed.[6] UCIL prepared an action plan, but UCC never sent a follow-up team to Bhopal. Many of the items in the 1982 report were temporarily fixed, but by 1984, conditions had again deteriorated.[61] In September 1984, an internal UCC report on the West Virginia plant in the USA revealed a number of defects and malfunctions. It warned that "a runaway reaction could occur in the MIC unit storage tanks, and that the planned response would not be timely or effective enough to prevent catastrophic failure of the tanks". This report was never forwarded to the Bhopal plant, although the main design was the same.[70]

According to the "Corporate Negligence" argument, workers had been cleaning out pipes with water nearby. This water was diverted due to a combination of improper maintenance, leaking and clogging, and eventually ended up in the MIC storage tank. Indian scientists also suggested that additional water might have been introduced as a "back-flow" from a defectively designed vent-gas scrubber. None of these theoretical routes of entry were ever successfully demonstrated during tests by the Central Bureau of Investigation (CBI) and UCIL engineers.[59][61][68][71]

A Union Carbide commissioned analysis conducted by Arthur D. Little claims that the Negligence argument was impossible for several tangible reasons:[58]

1. The pipes being used by the nearby workers were only 1/2 inch in diameter and were physically incapable of producing enough hydraulic pressure to raise water the more than 10 feet that would have been necessary to enable the water to "backflow" into the MIC tank.
2. A key intermediate valve would have had to be open for the Negligence argument to apply. This valve was "tagged" closed, meaning that it had been inspected and found to be closed. While it is possible for open valves to clog over time, the only way a closed valve allows penetration is if there is leakage, and 1985 tests carried out by the government of India found this valve to be non-leaking.
3. In order for water to have reached the MIC tank from the pipe-cleaning area, it would have had to flow through a significant network of pipes ranging from 6 to 8 inches in diameter, before rising ten feet and flowing into the MIC tank. Had this occurred, most of the water that was in those pipes at the time the tank had its critical reaction would have remained in those pipes, as there was no drain for them. Investigation by the Indian government in 1985 revealed that the pipes were bone dry.

Now owned by Dow Chemical Company, Union Carbide maintains a website dedicated to the tragedy and claims that the incident was the result of sabotage, stating that sufficient safety systems were in place and operative to prevent the intrusion of water.[72]

The Union Carbide-commissioned Arthur D. Little report concluded that it was likely that a single employee secretly and deliberately introduced a large amount of water into the MIC tank by removing a meter and connecting a water hose directly to the tank through the metering port.[58]

UCC claims the plant staff falsified numerous records to distance themselves from the incident and absolve themselves of blame, and that the Indian government impeded its investigation and declined to prosecute the employee responsible, presumably because it would weaken its allegations of negligence by Union Carbide.[73]

The evidence in favor of this point of view includes:

1. A key witness (the "tea boy") testified that when he entered the control room at 12:15 am, prior to the disaster, the "atmosphere was tense and quiet".
2. Another key witness (the "instrument supervisor") testified that when he arrived at the scene immediately following the incident, he noticed that the local pressure indicator on the critical Tank 610 was missing, and that he had found a hose lying next to the empty manhead created by the missing pressure indicator, and that the hose had had water running out of it.
3. This testimony was corroborated by other witnesses.
4. Graphological analysis revealed major attempts to alter logfiles and destroy log evidence.
5. Other logfiles show that the control team had attempted to purge 1 ton of material out of Tank 610 immediately prior to the disaster. An attempt was then made to cover up this transfer via log alteration. Water is heavier than MIC, and the transfer line is attached to the bottom of the tank. The Arthur D. Little report concludes from this that the transfer was an effort to transfer water out of Tank 610 that had been discovered there.
6. A third key witness (the "off-duty employee of another unit") stated that "he had been told by a close friend of one of the MIC operators that water had entered through a tube that had been connected to the tank." This had been discovered by the other MIC operators (so the story was recounted) who then tried to open and close valves to prevent the release.
7. A fourth key witness (the "operator from a different unit") stated that after the release, two MIC operators had told him that water had entered the tank through a pressure gauge.

The Little report argues that this evidence demonstrates that the following chronology took place:

• At 10:20pm, the tank was at normal pressure, indicating the absence of water.
• At 10:45pm, a shift change took place, after which the MIC storage area "would be completely deserted".
• During this period, a "disgruntled operator entered the storage area and hooked up one of the readily available rubber water hoses to Tank 610, with the intention of contaminating and spoiling the tank's contents."
• Water began to flow, beginning the chemical reaction that caused the disaster.
• After midnight, control room operators noticed the pressure rising and realized there was a problem with Tank 610. They discovered the water connection, and decided to transfer one ton of the contents out to try and remove the water.
• The MIC release then occurred.
• The cover-up activities discovered during the investigation then took place.
• After over 30 years, in November 2017, S. P. Choudhary, former MIC production manager, claimed in court that the disaster was not an accident but the result of a sabotage that claimed thousands of lives.

Chaudry's counsel, Anirban Roy, argued that the theory of design defects was floated by the central government in its endeavour to protect the victims of the tragedy. Everyone else who was part of investigations into the case "just toed the line of the central government.... The government and the CBI suppressed the actual truth and saved the real perpetrators of the crime."[74][75]

Roy argued to the district court that disgruntled plant operator M. L. Verma was behind the sabotage because he was unhappy with senior management. The counsel argued that there were discrepancies in the statements given by persons who were operating the plant at that time but the central agency chose not to investigate the case properly because it always wanted to prove that it was a mishap, and not sabotage. He alleged that Verma was unhappy with Chaudhary and Mukund.[76]

UCC chairman and CEO Warren Anderson was arrested and released on bail by the Madhya Pradesh Police in Bhopal on 7 December 1984. Anderson was taken to UCC's house after which he was released six hours later on $2,100 bail and flown out on a government plane. These actions were allegedly taken under the direction of then chief secretary of the state, who was possibly instructed from chief minister's office, who himself flew out of Bhopal immediately.[80][81][82] Later in 1987, the Indian government summoned Anderson, eight other executives and two company affiliates with homicide charges to appear in Indian court.[83] In response, Union Carbide said the company is not under Indian jurisdiction.[83]

From 2014, Dow is a named respondent in a number of ongoing cases arising from Union Carbide's business in Bhopal.[84]

Amulya Malladi's 2002 novel A Breath of Fresh Air relates the story of a mother and son who develop health issues as a result of exposure to gas at Bhopal. The book is based on Malladi's recollections of Bhopal during the incident.[102]

Indra Sinha released Animal's People in 2007. The novel tells the story of a boy who is born with a spinal condition due to effects of the gas. The book was shortlisted for the Man Booker Prize.

Arundhati Roy's 2017 novel The Ministry of Utmost Happiness which deals with many contemporary political issues in India, also features several characters still dealing with the aftermath of the gas leak.[103]

Annie Murray's novel Mother and Child (2019) is partly set in post-disaster Bhopal.[104]

• B. Dolan - RSVP (aka "Lucifer")
• Renaud - Morts les enfants
• Revolting Cocks - Union Carbide

In 1999, a Hindi film dealing with the tragedy, Bhopal Express, was released. The film stars Kay Kay Menon and Naseeruddin Shah.

In 2014, to coincide with the 30th anniversary of the disaster, historical-drama Bhopal: A Prayer for Rain was released, starring Martin Sheen as Union Carbide CEO Warren Anderson, Kal Penn, and Mischa Barton.[105]

The ninth episode of Swindled, an American true crime podcast, focused on the tragedy. The episode, titled "The Leak", was released on April 1, 2018.[106]

The tenth episode of The Family Man, an Indian action drama web television series on Amazon Prime Video, showcased how a terrorist recreated Bhopal gas tragedy in New Delhi.[107]

Protest in Bhopal in 2010

Soon after the accident, representatives from different activist groups arrived. The activists worked on organising the gas victims, which led to violent repression from the police and the government.[6]

Numerous actions have been performed: demonstrations, sit-ins, hunger strikes, marches combined with pamphlets, books, and articles. Every anniversary, actions are performed. Often these include marches around Old Bhopal, ending with burning an effigy of Warren Anderson.

Cooperation with international NGOs including Pesticide Action Network UK and Greenpeace started soon after the tragedy. One of the earliest reports is the Trade Union report from ILO 1985.[61]

In 1992, a session of the Permanent Peoples' Tribunal on Industrial Hazards and Human Rights took place in Bhopal, and in 1996, the "Charter on Industrial Hazards and Human Rights" was adopted.

In 1994, the International Medical Commission on Bhopal (IMCB) met in Bhopal. Their work contributed to long term health effects being officially recognised.

Important international actions have been the tour to Europe and United States in 2003,[110] the marches to Delhi in 2006 and 2008, all including hunger strikes, and the Bhopal Europe Bus Tour in 2009.

Bhopal People's Health and Documentation Clinic

At least 14 different NGOs were immediately engaged.[6] The first disaster reports were published by activist organisations, Eklavya and the Delhi Science Forum.

Around ten local organisations, engaged on long term, have been identified. Two of the most active organisations are the women's organisations—Bhopal Gas Peedit Mahila-Stationery Karmachari Sangh and Bhopal Gas Peedit Mahila Udyog Sangthan.[6]

More than 15 national organisations have been engaged along with a number of international organisations.[6]

Some of the organisations are:

• International Campaign for Justice in Bhopal (ICJB), coordinates international activities.
• Bhopal Medical Appeal, collects funds for the Sambhavna Trust.
• Sambhavna Trust or Bhopal People's Health and Documentation Clinic. Provides medical care for gas affected patients and those living in water-contaminated area.
• Chingari Trust, provides medical care for children being born in Bhopal with malformations and brain damages.
• Students for Bhopal, based in USA.
• International Medical Commission on Bhopal, provided medical information 1994–2000.

On 3 December 2004, the twentieth anniversary of the disaster, a man falsely claiming to be a Dow representative named Jude Finisterra was interviewed on BBC World News. He claimed that the company had agreed to clean up the site and compensate those harmed in the incident, by liquidating Union Carbide for US$12 billion.[111][112] Dow quickly issued a statement saying that they had no employee by that name—that he was an impostor, not affiliated with Dow, and that his claims were a hoax. The BBC later broadcast a correction and an apology.[113]

Jude Finisterra was actually Andy Bichlbaum, a member of the activist prankster group The Yes Men. In 2002, The Yes Men issued a fake press release explaining why Dow refused to take responsibility for the disaster and started up a website, at "DowEthics.com", designed to look like the real Dow website, but containing hoax information.[114]

The release of an email cache related to intelligence research organisation Stratfor was leaked by WikiLeaks on 27 February 2012.[115] It revealed that Dow Chemical had engaged Stratfor to spy on the public and personal lives of activists involved in the Bhopal disaster, including the Yes Men. E-mails to Dow representatives from hired security analysts list the YouTube videos liked, Twitter and Facebook posts made and the public appearances of these activists.[116] Journalists, film-makers and authors who were investigating Bhopal and covering the issue of ongoing contamination, such as Jack Laurenson and Max Carlson, were also placed under surveillance.[117][118] Stratfor released a statement condemning the revelation by Wikileaks while neither confirming nor denying the accuracy of the reports, and would only state that it had acted within the bounds of the law. Dow Chemical also refrained to comment on the matter.[119]

Ingrid Eckerman, a member of the International Medical Commission on Bhopal, has been denied a visa to visit India.[120]

• Methyl Isocyanate. Union Carbide F-41443A – 7/76. Union Carbide Corporation, New York (1976)
• Carbon monoxide, Phosgene and Methyl isocyanate. Unit Safety Procedures Manual. Union Carbide India Limited, Agricultural Products Division: Bhopal (1978)
• Operating Manual Part II. Methyl Isocyanate Unit. Union Carbide India Limited, Agricultural Products Division (1979).
• Bhopal Methyl Isocyanate Incident. Investigation Team Report. Union Carbide Corporation, Danbury, CT (1985).
• Presence of Toxic Ingredients in Soil/Water Samples Inside Plant Premises. Union Carbide Corporation, US (1989).